BMW K bikes (Bricks)


You are not connected. Please login or register

K100-forum.com » Technical, repair and troubleshooting » Engine and transmission » mechanical noise

View previous topic View next topic Go down  Message [Page 1 of 1]

1Back to top Go down   mechanical noise Empty mechanical noise Wed Dec 07, 2022 12:50 pm

attitude

attitude
active member
active member
Bike, K1100LT 1996, has been sitting for 2 weeks under its cover outside.  Finally got a warm dry day in portland Oregon and took bike to work.  12 mile ride warmed it up well.
At idle I now have a mechanical noise every 10 seconds, did not hear that at cold start up.  Very quick almost like an ignition miss but a mechanical noise.

Could this be the sprag clutch?  Pulling the clutch in does not change anything, still an intermittent noise.

thanks for sharing any advice or similar experience.

Jerome

    

2Back to top Go down   mechanical noise Empty Re: mechanical noise Wed Dec 07, 2022 4:35 pm

Arlina

Arlina
Moderator
Moderator
It's not the sprag.
Possible the cup of the generator, where the monkeynuts are.

Number 2;
https://www.realoem.com/bmw/nl/showparts?id=0522-EUR-05-1995-89V2-BMW-K_1100_RS_0522,0532_&diagId=12_0771

While you have the generator out, check the axle on radial play.


__________________________________________________
mechanical noise Eu-log10  K1100RS/LT - R1200RT - R1100RS - Cagiva SST 350 Ala Verde - K75LT project - K75 Schurgers - K75S - K1100RS - K75RT - K75C
    

3Back to top Go down   mechanical noise Empty Re: mechanical noise Wed Dec 07, 2022 6:06 pm

Point-Seven-five

Point-Seven-five
Life time member
Life time member
Arlina wrote:It's not the sprag.
Possible the cup of the generator, where the monkeynuts are.

Number 2;
https://www.realoem.com/bmw/nl/showparts?id=0522-EUR-05-1995-89V2-BMW-K_1100_RS_0522,0532_&diagId=12_0771

While you have the generator out, check the axle on radial play.
Monkey nutz are the first place I would check as well.  Sprags just slip, rather than make a bunch of noise.

While the bearings aren't normally a problem, it's worth checking while the alternator is out.


__________________________________________________
Present: 1991 K100RS "Moby Brick Too"
 
Past:
1994 K75RT "Ilsa, She Wolf of the SS"
1988 K100RS SE "Special Ed"
1994 K75S "Cheetos"
1992 K100RS "Moby Brick" R.I.P.
1982 Honda FT500
1979 Honda XR185
1977 Honda XL125
1974 Honda XL125
1972 OSSA Pioneer 250
1968 Kawasaki 175
    

4Back to top Go down   mechanical noise Empty Re: mechanical noise Wed Dec 07, 2022 9:25 pm

Laitch

Laitch
Life time member
Life time member
Point-Seven-five wrote:
Arlina wrote:It's not the sprag.
Possible the cup of the generator, where the monkeynuts are.
Monkey nutz are the first place I would check as well.  Sprags just slip, rather than make a bunch of noise.
attitude indicates this noise is made once every 10 seconds at ≈1000rpm which doesn't quite characterize it as a bunch. attitude also indicates that it's a mechanical noise but not whether it's a bing, ting, tink, tick, clang, clack, clunk, or knock, nor whether it falls into the category of cymbal, claves, castanets, cowbell, rimshot, gavel, grandfather clock or metronome. Perhaps the character of that noise could take center stage in the discussion. Laughing


__________________________________________________
1995 K75 90,000 miles
    

5Back to top Go down   mechanical noise Empty Re: mechanical noise Tue Dec 13, 2022 10:05 am

attitude

attitude
active member
active member
Well now the noise is every 3 seconds and sounds like a small hammer hitting metal softly. Idle surging a bit. Thinking that alternator bearings and or monkey nuts might be failing. Sound familiar?
Its been 34 degrees in the morning and bike stored outside under mc cover.

    

6Back to top Go down   mechanical noise Empty Re: mechanical noise Tue Dec 13, 2022 12:16 pm

Point-Seven-five

Point-Seven-five
Life time member
Life time member
Do you have someplace warm where you can work on this bike?  Pull the alternator off and check the monkey knutz and run the engine without it.  That will give another data point that might help us figure out what is going on.

Right now, what you are describing is not something that very few if any of the inmates have personally experienced.  Diagnosing an intermittent noise from a couple thousand miles away is difficult without some tests and inspections.  I know that I could really use some information on the status of your alternator.


__________________________________________________
Present: 1991 K100RS "Moby Brick Too"
 
Past:
1994 K75RT "Ilsa, She Wolf of the SS"
1988 K100RS SE "Special Ed"
1994 K75S "Cheetos"
1992 K100RS "Moby Brick" R.I.P.
1982 Honda FT500
1979 Honda XR185
1977 Honda XL125
1974 Honda XL125
1972 OSSA Pioneer 250
1968 Kawasaki 175
    

7Back to top Go down   mechanical noise Empty Re: mechanical noise Tue Dec 13, 2022 1:00 pm

Laitch

Laitch
Life time member
Life time member
What you can do without too much effort is check each spark plug to be sure its installed securely and inspect the coil wire connection to each spark plug to verify secure attachment to the plug. They shouldn't wiggle.


__________________________________________________
1995 K75 90,000 miles
    

8Back to top Go down   mechanical noise Empty Re: mechanical noise Tue Dec 13, 2022 9:27 pm

92KK 84WW Olaf

avatar
Life time member
Life time member
Or, as I discovered, exhaust stud issue left an exhaust flange los and occasionally rattling. It sounded like monkey nuts. So go under the head and check all the exhaust headers for studs and no loose flanges rattling.


__________________________________________________
1992 K100LT 0193214 Bertha Blue 101,000 miles
1984 K100RT 0022575 Brutus Baja Red 578 bought 36,000 now 89,150 miles
1997 K1100LT 0188024 Wotan Mystic Red 689 58,645 now 106,950 miles Deceased.
1983 K100RS 0011157 Fricka 606 Alaska Blue 29,495 miles Damn K Pox Its a Bat outta Hell Now 58,200 miles. 
1996 K1100LT 0233004 Lohengrin Mystic Red 38,000 miles currently 51,800 miles.
1983 K100RS 0004449 Odette R100 colours 58,000 miles. Sprint fairing now 63,390 miles

Past:
1968 Yamaha 80 YG1
1971 Yamaha 125 YAS-1
1968 Honda 125 SS
1970 Honda CD 175
1973 Honda CB500-4
Honda CX 500
    

Sponsored content


    

View previous topic View next topic Back to top  Message [Page 1 of 1]

K100-forum.com » Technical, repair and troubleshooting » Engine and transmission » mechanical noise

Permissions in this forum:
You cannot reply to topics in this forum